Study of the physical and chemical properties and essential fatty acids of sunflower oil used for frying for a period of (1-5) hours
DOI:
https://doi.org/10.52783/jns.v14.1593Keywords:
N/AAbstract
A portion of edible sunflower oil obtained from the local market was obtained and split into six segments. One segment served as the control sample, while the other five segments were used for frying for a duration of five hours. At each hour, a sample was extracted for inspection. The study included conducting chemical and physical testing on all samples. Additionally, gas chromatography (GC) analysis was performed to track the concentrations of essential fatty acids (namely linoleic and linolenic acids) in four oil samples. The obtained findings are as follows: Following a duration of five hours of frying, the melting point experienced a reduction of 2°C, the specific weight underwent a change from 0.9178 to 0.9255, the viscosity exhibited a rise from 40.82 to 48.70 CBP, and the refractive index had a modest alteration, transitioning from 1.4722 to 1.4735. The chemical tests yielded the following results: the free fatty acid content did not exceed 0.6%, the smoking point was reduced from 285°C to 245°C, the peroxide number remained within the permitted range without any modification, and the acidity level met the required specifications. The levels of unsaturated fatty acids in the control sample were as follows: oleic acid decreased from 263 ppm to 0.173 ppm, linoleic acid decreased from 102 ppm to 8.784 ppm, and linolenic acid decreased from 339 ppm to 17.27 ppm. Unsaturated acids exhibit less stability throughout the course of frying. The stability of the oil is directly correlated with the duration of frying. In general, sunflower oil is considered one of the most suitable oils for frying and remains stable for up to 5 hours of frying. The oil's essential acid concentration drops as the frying time increases, in addition to its physical qualities.
Downloads
Metrics
References
Abdulrahman, R. K. (2013). Sunflower oil production by utilizing Koya province agricultural crops. Chem. engin. dep. Koya university,Kurdistan. Koya as a Case Study.
Ahmad, S. N. S.; Tarmizi, A. H. A.; Abd Razak, R. A. ; Jinap, S. and Sulaiman, S. N.(2021). Selection of Vegetable Oils and Frying Cycles Influencing Acrylamide Formation in the Intermittently Fried Beef Nuggets. 10.3390/foods10020257.
Ahmed, A. M. and Nagy, E. Z. (2020). Effect of mixing ratio and heat treatment on some physical properties of vegetable oils. College of Agriculture - Tikrit University.
Al-Ali, R. M. and Al-Halfi, S. A. M. (2016). Studying the effect of adding natural antioxidants on the physical and chemical properties of corn oil used for deep frying. Dhi Qar University Journal of Agricultural Research, Volume 5 (1).
Al-Bayati, A. M. H.(1996). Food Processing, Second Division, University of Mosul, College of Agriculture and Forestry.
Al-Bilawi, S. K. S.(1988). Quality control and food standard specifications - first edition. Mosul University. Ministry of Higher Education and Scientific Research – Iraq.
ALMEIDA, D. T. ; VIANA, T. V. ; COSTA.M. M.; , SILVA, C, S.; FEITOSA, S.(2019). Effects of different storage conditions on the oxidative stability of crude and refined palm oil, olein and stearin (Elaeis guineensis). Food Sci. Technol, Campinas, 39(Suppl. 1): 211-217.
American Society for Nutrition.(2013). Adv. Nutr. 4: 311–312; doi:10.3945/an.113.003772.
AOAC. ( 2002) Official methods of analysis. 15th ed. Washington, DC, USA: The Association of the Official Analytical Chemists.
Ariponnammal S. A. (2012). Novel Method of Using Refractive Index as a Tool for Finding the Adultration of Oils. 79-85.
Ben Amer, M. E. ; Al-Moody, F. A. ; Hamza, M. M. and Hamza K. M. (2018). Determination of the acid number for Samples of peroxide, saponification and the numbers of local olive oil selected from some mills in the western region - Libya. Alzawia University. Journal of Colleges of Education No. 12.
Caldwell MD, Jonson HT, Othersen HB, Jr. Essential fatty acid deficiency in an infant receiving prolonged parenteral alimentation. J Pediatr. 1972;81:894-8.
fAo.(1986).Manuals of food quality control. Rome.ltaly.
14-Firestone. D.(1996).Regulation of frying fat and oil .lnDeep frying. che mistry.Nutrition, and practical Applications, perkins,E.G.and Erickson, M.D.,eds. ,Aocs press,champaign,IL,p.323.
Guide to Health Requirements for Frying Fats and Oils for the year (2019). Kingdom of Saudi Arabia.
Gulf Specification.(2008). Standardization Organization for the Cooperation Council for the Arab States of the Gulf G.C.C STANDARDIZATION ORGANIZATION (GSO).
Hassoun, K. (2012). Effect of falafel frying time on quality changes of cottonseed oil used in local markets. Damascus University, Journal of Agricultural Sciences - Volume (28) - Issue 2 - pp. 349-360.
Hladni N, Miladinović D. 2019. Confectionery sunflower breeding and supply chain in Eastern Europe. OCL 26–29. https://doi.org/ 10.1051/ocl/2019019
Imran,Muhammad1 and Nadeem,Muhammad(2015). Triacylglycerol composition, physicochemical characteristics and oxidative stability of interesterified canola oil and fully hydrogenated cottonseed oil blends. Lipids in Health and Disease 14:138 DOI 10.1186/s12944-015-0140-0.
Innawong B, Mallikarjunan P, Irundayaraj J, Marcy JE.( 2004).The determination of frying oil quality using Fourier transform infrared attenuated total reflectance. Lebensmittel-Wissenschaft undTechnologie, 37: 23-28.
IupAc, standard method 2-507.(1992).Determination of polar compounds in frying fats. ln standard Method for The Analysis of oils, fat, and Derivatives, lst supplement to The 7Th edition, lnternational union of pure and Applied chemistry ,ed. ,Blackwell, oxford, u.k.
Kakhia, T. I. (2006). Analysis of oils and fats and their raw and auxiliary materials.
Katkade. M. B.; Syed, H. M. ; Andhale, R. R.2 and Farooqui A. S1 (2018). Comparative study of physicochemical properties of different edible vegetable oils . An International Refereed, peer Reviewed & Indexed Quarterly Journal in science, Agriculture & Engineering . Vol VIII, Issue XXV , 2277-7601.
Kostik, V. ; Memeti, S. and Bauer, Bi. (2013) Fatty acid composition of edible oils and fats. Journal of Hygienic Engineering and Design, 4. pp. 112-116. ISSN 978-608-4565-03-1.
Kumar, p. Nayak,;Rayaguru,U. D. K. and Krishnan, K. R.(2016). Physio-Chemical Changes During Repeated Frying of Cooked Oil: A Review.food biochemistry First published.371-390. https://doi.org/10.1111/jfbc.12215
lnnawong, B,p.Mallikarjunan,J.lrundayaraj,and J.E,Merey. (2004a).The determination of frying oil quailty using fourier transform in franed attenuated total reflectsnce. lebensm-wiss.u-Technot. 37:23-28.
Mengistie, T. Alemu, A. and Mekonnen. A.(2018). Comparison of physicochemical properties of edible vegetable oils commercially available in Bahir Dar, Ethiopia. Chemistry International 4(2) 130-135.
Ngassapa, N. F.; Mwaisaka, R.T. and Nyandoro, S. S.(2016).Stability of traditionally processed vegetable oils and their blends under different storage conditions. Int. J. Biol. Chem. Sci. 10(5): 2341-2350.
Reshad, A. S. ; Tiwari, P. and Goud. V. V.(2017). Thermal Degradation Kinetic Study of Rubber Seed Oil and Its Methyl Esters under Inert Atmosphere. Energy Fuels , 31, 9, 9642–9651.
Sibai, H. and Alrifaie, H.(2018).The Effect of Frying Conditions on Sunflower Oil Attributes. Tikrit Journal of Engineering Sciences , 25 (2) 52 – 58.
Pearson,D.(1977).The chemical analysis of food. 7Th ed. chemical publishing gco. lnc. New york. u .s.A.
Pankaj, S.K.; Keener, K.M.(2017). A review and research trends in alternate frying technologies. Curr. Opin. Food Sci. 16, 74–79.
Pilorgé, E.; Inovia,T. and Brétignières, Av L. (2020). Sunflower in the global vegetable oil system: situation, specificities and perspectives. Terres Inovia, Av L. Bretignieres, F78850 Thiverval-Grignon, France. OCL, 27, 34. by EDP Sciences. https://doi.org/10.1051/ocl/2020028.
Putnam ,D.H.;E.S; Oplinger ; D.R.Hicks; B.R.Dargan; D.M. Notzel ;R.A.Meronuck ; J.D.Dol and E.E. Schalte .2008 . Sunflower Alternative field Crops Manual .Last up dated : Thumar 27,10:5-10.
Taylor and Francis Group (2006)Frying of Foods Vassiliki Oreopoulou, Magdalini Krokida, and Dimitris Marinos-Kouris.
Vieira, S.A.; Zhang, G.; Decker, E.A. Biological Implications of Lipid Oxidation Products. J. Am. Oil Chem. Soc. 2017, 94, 339–351.
Wang, W. ; Gan, Y. ; Kan, H. ; Mao, X. and Wang, Y. (2021). Exploitation of HPLC Analytical Method for Simultaneous Determination of Six Principal Unsaturated Fatty Acids in Oviductus Ranae Based on Quantitative Analysis of Multi-Components by Single-Marker (QAMS) Shihan. Molecules, 26, 479. https://doi.org/10.3390/molecules26020479.
White, A.; P. Handler and E.L.Smith. (1973). Principles of Biochemistry. 5 th ed. Mc Graw- Hill, Kogakush.
Downloads
Published
How to Cite
Issue
Section
License
This work is licensed under a Creative Commons Attribution 4.0 International License.
You are free to:
- Share — copy and redistribute the material in any medium or format
- Adapt — remix, transform, and build upon the material for any purpose, even commercially.
Terms:
- Attribution — You must give appropriate credit, provide a link to the license, and indicate if changes were made. You may do so in any reasonable manner, but not in any way that suggests the licensor endorses you or your use.
- No additional restrictions — You may not apply legal terms or technological measures that legally restrict others from doing anything the license permits.
